The 16"/50 caliber Mark 7 – United States Naval Gun is the main armament of the Iowa-class battleships and was the planned main armament of the cancelled .
Description
Due to a lack of communication during design, the Bureau of Ordnance assumed the Iowa class would use the /50 Mark 2 guns constructed for the 1920 South Dakota-class battleships. However, the Bureau of Construction and Repair assumed that the ships would carry a compact 16-in/50 turret and designed the ships with barbettes too small to accommodate the 16-in/50 Mark 2 three-gun turret that the Bureau of Ordnance was actually working on. The lightweight 16-in/50 Mark 7 was designed to resolve this conflict.
These guns were 50 calibers long, 50 times their bore diameter with barrels long, from chamber to muzzle. Each gun weighed about without the breech, and with the breech. They fired projectiles weighing from at different muzzle velocities, depending on the shell. When firing armor-piercing shells, their muzzle velocity was 2,500 feet per second (762 meters per second) with a range of up to . At maximum range the projectile spent almost minutes in flight. Each turret required a crew of 79 men to operate. The turrets cost US$1.4 million each, excluding the cost of the guns.
The turrets were described as "three-gun" rather than "triple" because each barrel could be elevated independently. The ships could fire any combination of their guns, up to a broadside of all nine. The turret interiors were subdivided and designed to permit the independent loading, elevation and firing of each gun. Each turret was fitted with an optical range finder, ballistic analog computer, and a switchboard. The rangefinder and ballistic computer permitted the turret's gun captain and crew to locally engage targets should battle damage disrupt communication with the ship's primary or auxiliary fire control centers. The firing switchboard allowed any remaining fire control computer to send data to or control the firing computers of other turrets in the event of battle damage to the primary and secondary artillery plotting rooms.
Contrary to popular belief, the ships did not move sideways noticeably when a broadside was fired; this was an illusion. With the enormous mass of the vessel and the damping effect of the water around the hull, the pressure wave generated by the gunfire was felt as just a slight change in lateral velocity. The sea surface on the side of the ship to which the guns are trained is roiled by the guns' muzzle blast, which creates the illusion of motion in still photos.
The guns could be elevated from −5 degrees to +45 degrees, moving at up to 12 degrees per second. The turrets could rotate about 300 degrees at about 4 degrees per second and could be fired back beyond the beam, sometimes called firing "over the shoulder". A red stripe on the wall of each turret, inches from the railing, marked the limit of the gun's recoil as a safety warning to the turret's crew.
Complementing the 16-in/50 caliber Mark 7 gun was a fire control computer, the Ford Instrument Company Mark 8 Range Keeper. This analog computer was used to direct the fire from the battleship's big guns, taking into account factors including the speed of the targeted ship, the projectile's travel time, and air resistance. At the time the was set to begin construction, the range keepers had gained the ability to use radar data to direct fire. The results of this advance were telling: the range keeper was able to track and fire at targets at greater range and with increased accuracy, day or night. This gave the US Navy a major advantage in the latter half of WWII, as the Japanese did not develop radar or automated fire control to the level of the US Navy. With a few exceptions, such as the Japanese battleship Yamato, Japanese warships at best used basic radar sets that were not connected to fire control, still relying on optical rangefinders. Even the few Japanese warships that had radar-assisted guns did not directly link their fire control and radar, having to input the locations of targets spotted on radar into the fire control manually.