“These American waggons,” says Thrupp, “were modelled from the old German waggon, but they have been so much improved as to be scarcely recognised. The distinctive feature of the German waggon was a light, shallow tray, suspended above a slight perch carriage on two grasshopper springs placed horizontally and parallel with and above the front and hind axle-tree; on the tray one or two seats were placed, the whole was light and inexpensive, and well adapted to a new, rough country without good roads. These waggons may still be found in Germany and Switzerland....
“American ingenuity was lavished upon these waggons, and they have arrived at a marvel of perfection in lightness. The two grasshopper springs have been replaced with two elliptical springs. The perch, axle-trees, and carriage timbers have been reduced to thin sticks. The four wheels are made so slender as to resemble a spider’s web; in their construction of the wheels the principle of the patent rim used in England in 1790 has been adopted. Instead of five, six, or seven felloes to each wheel, there are only two, of oak or hickory wood, bent to the shape by steam. The ironwork of the American buggy is very slender, yet composed of many pieces, and, in order to reduce the cost, these pieces of iron are mostly cast, not forged, of a sort of iron less brittle than our cast iron.... The weight of the whole waggon is so small that one man can lift it upon its wheels again if accidentally upset, and two persons of ordinary strength can raise it easily from the ground. The four wheels are nearly of the same height, and the body is suspended centrally between them. There are no futchels; the pole or shafts are attached to the front axle-tree bed, and the front of the pole is carried by the horses just as they carry the shafts; the splinter-bar and whipple-trees are attached to the pole on swivels. Some are made without hoods and some with hoods. These are made so that the leather of the sides can be taken off and rolled up, and the back leather removed, rolled, or fixed at the bottom, a few inches away from the back, the roof remaining as a sunshade....
“The perfection to which the American buggy or waggon has been carried, and every part likely to give way carefully strengthened, is marvellous. Those made by the best builders will last a long time without repair. The whole is so slender and elastic that it ‘gives’—to use a trade term—and recovers itself at any obstacle. The defect in English eyes of these carriages consists in the difficulty of getting in or out by reason of the height of the front wheel, and its proximity to the hind wheel—it is often necessary partly to lock round the wheel to allow of easy entrance. There is also a tremulous motion on a hard road which is not always agreeable. It is not surprising that, with the great advantages of extreme lightness, ease, and durability, and with lofty wheels, the American waggons travel with facility over very rough roads, and there is a great demand for them in our colonies. It must be remembered that the price is small, less than the price of our gigs and four-wheeled dog-carts.”
